Home:

flotation lead with pyrrhotite

flotation lead with pyrrhotite

Pyrrhotite Depressant in Polymetallic Flotation - Froth .

Froth Flotation (Sulphide & Oxide) . In general, flotation of pyrrhotite is depressed in the range of about pH 9.3 and above. Note that this is not just a pH effect - sodium hydroxide and sodium carbonate are not particularly effective. The third depressant is redox (eH). When the redox is low, pyrrhotite

More

Froth Flotation Method | Gold and Silver Ore Flotation .

Dec 20, 2018 · The flotation of gold and silver minerals is mostly carried out in alkaline pulp medium, but for some gold-bearing pyrite and pyrrhotite, it is suitable for flotation in weak acid pulp medium. Oxygen has an effect on the flotation process of gold-silver sulfide ore oxidized to different degrees.

More

A review of pyrrhotite flotation chemistry in the .

The use of trithiocarbonates for pyrrhotite flotation is one example of collector development as an alternative to the traditional xanthate collectors. With regard to oxidation potential control, the use of inert gas flotation for the processing of PGM ores has been demonstrated (Gathje and Simmons, 2004) and is being evaluated further.

More
Cited by: 93

The Effect of Oxidation on the Flotation Behaviour of .

On the other hand, preferential oxidation of pyrrhotite may lead to a selectivity increase in flotation. Such a behaviour has been noted in the flotation of a pyrrhotite-rich process stream. The results have been discussed in the light of fundamenLal electrochemical interactions involving pentlandite, chalcopyrite, pyrrhOlite, pyrite and grinding

More

Depressants and dispersants - Huntsman Corporation

Iron sulfide (pyrite, pyrrhotite, marcasite) depressant used in the flotation separation of base metal sulfides. Alternative partial cyanide replacement to depress iron and zinc sulfides in Pb / Zn flotation. UNIMAX ® SD300. A specialty depressant for pyrite gangue, sphalerite and pyrrhotite in lead and copper flotation systems .

More

Ultrafine Grinding - an overview | ScienceDirect Topics

The pyrrhotite concentrate produced by flotation was used to determine the leaching strategy at the oratory scale. . Bulk flotation of lead and zinc minerals may in such cases have a number of economic advantages. Coarse primary grinding is often sufficient with bulk flotation, as the valuable minerals need be liberated only from the .

More

Depressants and dispersants - Huntsman Corporation

Iron sulfide (pyrite, pyrrhotite, marcasite) depressant used in the flotation separation of base metal sulfides. Alternative partial cyanide replacement to depress iron and zinc sulfides in Pb / Zn flotation. UNIMAX ® SD300. A specialty depressant for pyrite gangue, sphalerite and pyrrhotite in lead and copper flotation systems .

More

(PDF) A Review on Pyrrhotite Oxidation - ResearchGate

A Review on Pyrrhotite Oxidation. . Associated increases in mineral volume can lead to spalling, cracking and a loss of structural integrity. . The flotation performance improved with the .

More

The flotation of magnetic and non-magnetic pyrrhotite from .

The non-stoichiometric sulfide mineral pyrrhotite (Fe (1− x) S), common to many nickel ore deposits, occurs in different crystallographic forms and compositions. A series of pyrrhotite samples derived from Canada, South Africa and Botswana whose mineralogy is well characterised, were selected here in order to develop the relationship between mineralogy and flotation performance.

More

AMENABILITY OF COLUMN FLOTATION FOR LEAD-ZINC .

Metals Materials And Processes, 1998, Vol. 10,No.2, pp. 109-]]8. ©Meshap Science Publishers, Mumbai, 1ndia. AMENABILITY OF COLUMN FLOTATION FOR LEAD-ZINC BENEFICIATION

More

Pyrite Flotation Zinc - australiandenbosch

Iron sulfide (pyrite, pyrrhotite, marcasite) depressant used in the flotation separation of base metal sulfides. Alternative partial cyanide replacement to depress iron and zinc sulfides in Pb / Zn flotation. UNIMAX ® SD300. A specialty depressant for pyrite gangue, sphalerite and pyrrhotite in lead and copper flotation systems .

More

Effects of Process Parameters on Selective Flotation of .

Effects of Process Parameters on Selective Flotation of Lead-Zinc Ore R. Singh, B. Banerjee and J.P. Srivastava Mineral Processing Division, National Metallurgical Laboratory, Jamshedpur - 831 007 e-mail: [email protected] Abstract The present deals with the results of the characterisation and flotation studies carried out on a typical lead .

More

(PDF) A review of pyrrhotite flotation chemistry in the .

Contact angle at pyrrhotite surface with and without lead detected on concentrate particles from actual flotation activation as a function of pH in the presence of SIBX (1 · 10 4 M) at circuits operating at pH 9 (Yoon et al., 1995), indicating ambient temperature and 0.05 M Na2SO4 (University of Utah, 2004). that pyrrhotite was effectively .

More

Depressants for Pyrrhotite / Flotation depressants .

Flotation results indicate that PIONERA BioPolymers, at each dosage, significantly reduce pyrrhotite more than conventional depressants. Additionally, conventional pyrrhotite depressants such as sodium cyanide, sodium hydro sulfide and Nokes reagent are toxic, highly regulated, difficult to handle and present an overall costly alternative.

More

Chapter 1 INTRODUCTION - UPSpace

recognised in a variety of ore deposits including nickel-copper, lead-zinc, and platinum group element (PGE). Since the principal nickel ore mineral, pentlandite, almost ubiquitously occurs coexisting with pyrrhotite, the understanding of the behaviour of pyrrhotite during flotation is of fundamental interest.

More

Gold-Pyrite ores - Danafloat - Home

Where the gold is intimately associated with various sulphide minerals, especially iron sulphides which include pyrite, arsenopyrite and pyrrhotite, flotation recovery of the gold is dependent on recovery of the associated minerals. In this case gold follows the associated sulphide mineral recovery.

More

(PDF) Pyrite and pyrrhotite open circuit potentials study .

Chloride ions after reaction with lead produce chloride Comparison between the effect of chloride and sulfate ions on compounds that have high solubility (Cisneros et al., 2000). pyrite, pyrrhotite and steel shows that chloride ion is more effec- Another reason for reduction of open circuit potential in the tive than sulfate ion in reducing the .

More

Introductions for the Ore Flotation Solutions of the .

Secondly, separating the mixture of concentrate copper and lead: first of all, using CMC of postassium dichromate method to suppress lead and float copper, and adopt B butter and 2# oil as collector and frother to make stable flotation foam thus can get good copper concentrate.

More

Method of pyrrhotite-bearing ores flotation

Activator flotation of pyrrhotite is the presence in the slurry of copper ions [1]. Known ability of pyrrhotite intensively to absorb oxygen from the liquid phase of the pulp caused by the oxidation of the surface of the mineral, as well as to the formation of sludge during grinding.

More

Copper activation option for a pentlanditepyrrhotite .

May 30, 2016 · Introduction. Different sulphide ores respond differently in the prospect of copper activation to thiols for froth flotation. With the BCL Selebi-Phikwe ore body, pentlanditepyrrhotitechalcopyrite co-occur and there is the constraint of fine pentlandite dissemination in the pyrrhotite, so that liberation is limited.

More

Gold-Pyrite ores - Danafloat - Home

Where the gold is intimately associated with various sulphide minerals, especially iron sulphides which include pyrite, arsenopyrite and pyrrhotite, flotation recovery of the gold is dependent on recovery of the associated minerals. In this case gold follows the associated sulphide mineral recovery.

More

(PDF) Pyrite and pyrrhotite open circuit potentials study .

Chloride ions after reaction with lead produce chloride Comparison between the effect of chloride and sulfate ions on compounds that have high solubility (Cisneros et al., 2000). pyrite, pyrrhotite and steel shows that chloride ion is more effec- Another reason for reduction of open circuit potential in the tive than sulfate ion in reducing the .

More

Copper activation option for a pentlanditepyrrhotite .

May 30, 2016 · Introduction. Different sulphide ores respond differently in the prospect of copper activation to thiols for froth flotation. With the BCL Selebi-Phikwe ore body, pentlanditepyrrhotitechalcopyrite co-occur and there is the constraint of fine pentlandite dissemination in the pyrrhotite, so that liberation is limited.

More

Effects of Process Parameters on Selective Flotation of .

Effects of Process Parameters on Selective Flotation of Lead-Zinc Ore R. Singh, B. Banerjee and J.P. Srivastava Mineral Processing Division, National Metallurgical Laboratory, Jamshedpur - 831 007 e-mail: [email protected] Abstract The present deals with the results of the characterisation and flotation studies carried out on a typical lead .

More

Review of the effect of grinding media on flotation of .

Similar results were also observed by Thornton [37] on three Canadian ores, which each showed faster zinc flotation in copper and lead flotation stages after grinding without steel media. Bruce [3] found the same, though in this case the depressing effect of autogenous grinding on pyrite flotation led to

More

Introductions for the Ore Flotation Solutions of the .

Secondly, separating the mixture of concentrate copper and lead: first of all, using CMC of postassium dichromate method to suppress lead and float copper, and adopt B butter and 2# oil as collector and frother to make stable flotation foam thus can get good copper concentrate.

More

Namib Lead & Zinc Mine Updates Resources and Reserves

• Cyanide addition to depress sphalerite in lead flotation is far superior to the use of zinc sulphate. The use of cyanide also has a tangible effect on the depression of both pyrite and pyrrhotite to the extent that flotation response appears to be independent of the relative proportions of pyrite/pyrrhotite in the ore.

More

The method of flotation of sulphide ores containing .

Cialisbuy lead-zinc ore containing pyrites and arsenopyrite are ismalic is of well-known collector of xanthate and blowing agent was flotirovanija lead-pyrrhotite-arsenopyrite concentrate, which method prototype has been air with activated carbon (10 kg/t) and air in a calcareous environment (St. CaO 1.5 g/l) for 30 min, mixed with the .

More

USE OF NON-TOXIC DEPRESSANTS IN THE SELECTIVE

The separation of lead, copper and zinc concentrates from the ore sample was achieved using collective and selective flotation methods. Prior to flotation tests the ore sample was ground below 200 µ m by controlled screening. The metal contents and distributions

More

US2342277A - Separation of pyrite, arsenopyrite, and .

US2342277A US474491A US47449143A US2342277A US 2342277 A US2342277 A US 2342277A US 474491 A US474491 A US 474491A US 47449143 A US47449143 A US 47449143A US 2342277 A US2342277 A US 2342277A Authority US United States Prior art keywords arsenopyrite pyrite flotation pyrrhotite permanganate Prior art date Legal status (The legal status is an assumption

More

Development of a Combined Flotation and High Pressure .

istence with gangue minerals of pyrrhotite, pyrite and other clay minerals. In the second stage, key parameters, particularly concentration of sulfuric acid, . The flotation experiments were carried out at a stirring speed of 400 rpm and air . an increase in PAX concentration lead to drastic increases in the grade and recovery of copper .

More

Flotation performances of polymorphic pyrrhotite .

Abstract. The floatability of different crystalline structures of pyrrhotite (monoclinic and hexagonal) was studied. It is shown that the floatability of monoclinic and hexagonal has obvious difference, and that the flotation recovery of monoclinic pyrrhotite is larger than that of hexagonal pyrrhotite

More

Flotation of gold and gold-bearing ores - PDF Free Download

The adsorption of copper onto pyrite and pyrrhotite is Flotation of gold and gold-bearing ores 317 . lead nitrate was added as an activator to assist in the preferential flotation of arsenopyrite from pyrrhotite (Bax and Bax, 1993), while lead acetate was used at the Surcease Mine in California to produce a bulk sulfide concentrate for .

More

US4460459A - Sequential flotation of sulfide ores - Google .

A sequential flotation process for the recovery of high-grade concentrates of copper, lead and cobalt-nickel from sulfide ores is provided. A primary grind ore pulp is conditioned with SO 2 as H 2 SO 3 under intense aeration, and the conditioned pulp subjected to sequential flotation, with regrinding and conditioning of a copper rougher concentrate obtained in the first flotation step for copper.

More